Product ID:0532 COFFEE, AEROSOL SPRAY PAINT
MSDS Date:03/23/1988
FSC:8010
NIIN:00N027609
MSDS Number: BPGPY

ZYNOLYTE PRODUCTS CO

2320 E DOMINGUEZ ST
CARSON, CA 90749
US

Emergency Phone: 310-513-0700

Info Phone: 310-513-0700

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

COBALT OCTOATE 6%

PROPANE

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1000 PPM

ACGIH TLV: SIMPLE ASPHYXIANT

8 @ 20C.

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 150 PPM;200 STEL

ACGIH TLV: 150 PPM;200 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

HYDROTREATED HEAVY NAPHTHA

CAS: 64742-48-9

PROPANE, 2-METHYL-; (ISOBUTANE)

CAS: 75-28-5

RTECS: TZ4300000

IRON OXIDE

CAS: 1309-37-1

RTECS: NO7400000

OSHA PEL 10 MG/M3 (FE)

ACGIH TLV: 5 MG/M3(FE),B2; 9293

36.7 @ 20C.

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

5.5 @ 20C.

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

25.0 @ 20C.

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC

CAS: 64742-95-6

RTECS: WF3400000

OSHA PEL 25 PPM (MFR)

ACGIH TLV: 25 PPM (MFR)

10 @ 20C.

CAS: 64742-94-5

RTECS: WF3100000

2 @ 20C.

CAS: 64742-88-7

26 @ 20C.

CAS: 64742-89-8

OSHA PEL 300 PPM,400 STEL

ACGIH TLV: 300 PPM

400 @ 20C.

CAS: 75-09-2

RTECS: PA8050000

OSHA PEL 500 PPM, C

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

POLYMER; (NON-HAZARDOUS POLYMER)

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST:GI DISTRESS. INHAL: OVEREXP MAY
CAUSE NOSE/THROAT IRRIT. MAY CAUSE CNS EFTS SUCH AS DIZZ, HDCH,
NAUS, STAG GAIT, CONFUSION & UNCON. RPTS HAVE ASSOC RPTD/PRLNGD
OVEREXP TO SOLV W/PERM BRAIN & NE RV SYS DMG. EYE: MAY CAUSE EYE
IRRIT/BURNING OF EYES. SKIN: RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN
IRRIT/ (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: GROUP 2 (NTP), 2B
(IARC). NICKEL: GROUP 2 (NTP), 2B (IARC).
Effects of Overexposure:HLTH HAZ: BURNING OF EYES. SKIN: RPTD/PRLNGD
LIQ CONT MAY CAUSE SKIN IRRIT W/DISCOMFORT/DERM. CHLOROCARBON MATLS
HAVE PRDCD SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS &
COULD HAVE SIMILAR EFFE CT IN HUMANS. ADRENOMIMETICS (E.G.,
EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES
IN (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGESTION: CALL PHYSICIAN IMMED AND HAVE NAMES OF INGREDIENTS
AVAILABLE. DO NOT INDUCE VOMITING. INHALATION: REMOVE TO FRESH AIR.
IF NOT BREATHING, GIVE ARTF RESP, PREFERABLY MOUTH TO MOUTH. IF
BREATH ING DFCLTY PERSISTS, OR OCCURS LATER, CONSULT PHYSICIAN.
EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES; CALL PHYSICIAN. SKIN: WASH W/SOAP & H*2O. IF IRRIT OCCURS,
CONT PHYSICIAN.

Flash Point Method:COC
Flash Point:<20F,<-7C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESS DEMAND SCBA &
FULL PROT EQUIP . H*2O MAY BE INEFT. H*2O FROM FOG NOZ MAY BE USED
TO COOL CLSD CNTNRS TO PVNT PRESS BUILDUP.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESS.KEEP AT ROOM TEMP AS
EXPOS TO SUNLIGHT/OTHER HEAT MAY CAUSE CANS TO BURST, PROPELLING
CONTENTS ACROSS AREA. THERM DECOMP PRODS MAY (SUPDAT)

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE
WITH INERT ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS AND FLAME. DO NOT STORE ABOVE 120F. DO NOT EXPOSE
TO DIRECT SUNLIGHT TO AVOID BURSTING.
Other Precautions:DO NOT SAND,FLAME CUT,BRAZE/WELD DRY COATING W/OUT
NIOSH/MSHA APPRVD RESP/APPROP VENT. DO NOT PUNCTURE. DO NOT SPRAY
NEAR FIRE/OPEN FLAME. NO SMOKING IN AREA OF USE. DO NOT USE IN GEN
VICINITY OF ARC WELDING, OPEN FLAMES/HOT SURFS. (SUPDAT)

Respiratory Protection:WEAR AN APPROPRIATE NIOSH/MSHA APPROVED PROPERLY
FITTED RESPIRATOR DURING AND AFTER APPLICATION UNLESS AIR
MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE BELOW APPLICABLE
LIMITS.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:COVERALLS. PROTECTIVE CREAMS MAY BE USED FOR
EASE OF CLEAN-UP, NOT FOR PROTECTION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING AND SMOKING.
Supplemental Safety and Health
SOL IN H*2O: APPRECIABLE, DEPENDING ON COLOR.EXPLO HAZ: INCL HCL &
PHOSGENE . EFTS OF OVEREXP: HUMANS ACUTELY/CHRONICALLY EXPOS TO
CHLOROCARBONS . FOR MORE EXACTING INFO CONCERNING INDIV I NGRED
HLTH HAZ CONT NEHC . OTHER PREC: HEAT AND/OR UV RADIATION MAY CAUSE
FORMATION OF HCL AND/OR PHOSGENE .

HCC:V3
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.745
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:MODERATE-(SUPP DATA)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:92

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:CO, CO*2, SMOKE, OXIDES OF HEAVY
METALS REPORTED IN INGRED SECTION. HCL, PHOSGENE .

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.